Quote
My unit leaked atf from the Jeep tailhousing once installed.

Bit of googling said i should have used a seal extension in the Jeep tailhousing. Anyway I sealed up the oil hole & its all been good so far. Just didnt want to pull it all out again, but I did buy the extension & will put in it (if I need to take it apart again). I'm no too fussed about fluid transfer between the 3 units (if there is any) as all 3 , ie tranny, doubler & NP242 are all running atf.


cheers


Do you have a pic or link for this? I did some googling but I'm not even sure what I'm looking for so I don't know if I found it or not.

Edward

'97 Montero Sport LS 5-Speed 3.5L conversion
SAS Dana 44s & ARBs, 35" Yoko Geolandar M/Ts
NP231 B4R doubler/Terra Low231/RP 5.38 229:1
'99 Montero Sport Limited 4WD SAS 3-link project
'03 Montero Sport Limited AWD
'97 Montero Sport LS 5-Speed 4WD